
	Trending ▼ ICSE CBSE 10th ISC CBSE 12th CTET GATE UGC NET Vestibulares ResFinder

Case operation

10 pages, 0 questions, 0 questions with responses, 0 total responses,

	83060359	+Fave Message
	Profile Timeline Uploads

Home > 83060359 >

Formatting page ...

OPEA/004 I BS Center for Management Research Operations Management at Southwest Airlines This case was written by R.Muthu Kumar, under the direction of A.V. Vedpuriswar, IBS Center for Management Research. It was compiled from published sources, and is intended to be used as a basis for class discussion rather than to illustrate either effective or ineffective handling of a management situation. 2004, IBS Center for Management Research. All rights reserved. To order copies, call +91-08417-236667/68 or write to IBS Center for Management Research (ICMR), IFHE Campus, Donthanapally, Sankarapally Road, Hyderabad 501 504, Andhra Pradesh, India or email: info@icmrindia.org www.icmrindia.org License for IBS Hyderabad, Sem II, Class of 2014. OPEA/004 Operations Management at Southwest Airlines It s easy to offer great service at high cost. It s easy to offer lousy service at low cost. What s tough is offering great service at low cost, and that s what our goal is. To do it, we have to watch every penny. I personally approve all expenditures over $1,000, not so much because I don t trust our people, because I know that if they know I m watching, they ll be just that much more careful. --Herb Kelleher, the Chairman of Southwest Airlines Introduction In 2003, Southwest Airlines (Southwest) was the fourth largest1 US airline in terms of domestic customers carried. The airline s major short haul, low-fare, high frequency, and point-to-point carrier in the US covered 60 cities (59 airports) in 30 states. It was the first airline to introduce a homepage on the Internet. Southwest had enjoyed 30 straight profitable years. Southwest had the best customer complaint record of any US airline for the last 12 years. In 2003, Southwest was named by Fortune as one of the most admired companies in US. In November 2003, Southwest achieved a 9.4% increase in traffic due to Thanksgiving Day2. It also recorded 3.76 million revenue passenger miles up from 3.44 million for the same period in the previous year. Its load factor3 was 63.7% up from 60.5% in November 2002. Figure (i) Southwest s Market Share in 2002 Source: www.southwest.com Background Note In 1967, Texas businessman Rollin King and lawyer Herb Kelleher founded Southwest as an intrastate airline, linking Dallas, Houston, and San Antonio. In 1971, Southwest made its first scheduled flight. Operating from Love Field Airport in Dallas, Southwest adopted love as the theme of its early ad campaigns. While other airlines moved to the new Dallas/Fort Worth Airport 1 2 3 After American airlines (AMR), Delta, and Jet blue. A day for remembering remarkable military men. The Thanksgiving weekend is one of the most traveled periods during the year. It was a percentage of total passengers carried. 1 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines (DFW) in 1974, Kelleher insisted on staying at Love Field, and gained a virtual monopoly there. When Lamar Muse, Southwest s president, resigned in 1978, Kelleher was elected as president and Chief Executive Officer. Thus began the career of one of the America s most popular business leaders. In 1979, Southwest started its new service to New Orleans from Dallas, the first city outside Texas. In 1982, Southwest extended its services to San Francisco, Los Angeles, San Diego, Las Vegas, and Phoenix. Southwest launched the Just Say When4 campaign in 1985, which established it as the point-to-point carrier in the nation. Southwest introduced advance-purchase Fun Fares5 in 1986, and a frequent-flier program6 in 1987, which was based on the number of flights taken instead of mileage. Southwest and Sea world of Texas7 joined to promote Texas as a major tourist place. In 1986, Southwest was announced as Sea world of Texas s official airline and the official airline of California. In 1992, Southwest won the first Triple Crown8 Award for the month of January and won the annual Triple Crown Award. Southwest managed to receive that award without a break till 1996. Southwest moved into the East Coast with a service to Baltimore in 1993 and bought Salt Lake City-based Morris Air in 1994. In 1996, Southwest expanded into Florida and started selling tickets through its Web site (www.southwest.com). Agreements with Icelandair allowed Southwest passengers to connect from four US cities to Europe through Icelandair s Baltimore hub. In 1998, Southwest flew its first nonstop transcontinental flight, from Oakland, California, to Baltimore. In 1999, Southwest added more routes in the East (from Islip to Raleigh-Durham, Nevada, Hartford). In 2000, Southwest had its first major accident, when a Boeing 737 aircraft overran the end of a runway in Burbank, California, and came to a halt in a busy street. But the accident caused only minor injuries. Southwest introduced SWABIZ9, a software tool that assisted company travel managers in booking and tracking trips made through its website. Later that year, Southwest placed its biggest aircraft order ever, calling for delivery of another 94 Boeing 737 aircraft between 2002 and 2007. In 2001, on its 30th anniversary, Southwest changed its logo and added blue to its traditional color scheme of gold, red, and orange. That same year, Southwest experienced a rare labor dispute, when stalled contract negotiations led to picketing by the airline s ground crew union. Kelleher stepped down as president and CEO in 2001 and was succeeded by General counsel Jim Parker. Despite an industry wide downturn following the September 11, 2001 terrorist attacks, Southwest managed to post a profit for 2001 as well as 2002. In the face of weak demand for air service, most major airlines significantly reduced service, grounded aircraft, and retrenched employees. UAL, the parent of United Airlines, and US Airways sought relief from financial obligations in bankruptcy10 and other smaller carriers ceased operation entirely. But Southwest maintained a full flight schedule and avoided layoffs. 4 5 6 7 8 9 10 It was the reward scheme for customers. In advance purchase Fun Fares, fares were reduced by 25%, if it was booked before 14 days. It was weekend Fun Packs, which included roundtrip airfare and hotel charges for its regular customers. Texas state tourism development department. For best on time record, best carrier handling, and fewest customer complaints. SWABIZ was Southwest s online corporate travel booking tool. Inability to pay debt. 2 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Figure (ii) Southwest s Revenue and Net income Source: www.southwest.com Southwest also continued to strengthen its presence in the east coast of the US. It took advantage of the cutbacks in services by major carriers, by adding five nonstop transcontinental flights. Its latest eastern expansion project was at the Philadelphia International Airport, which it planned to serve with 14 daily flights. The year 2002 was the worst year ever for the airline industry. A sluggish economy, radical changes in airport security, high-energy prices, and tension in the gulf spelled financial disaster for the major airlines. Despite all this, Southwest posted its 30th consecutive annual profit. No other airline had equaled this record of profitability. Operations Southwest s business model revolved around providing safe, reliable, and short duration air service at the lowest possible fare. With an average aircraft trip of roughly 400 miles, the company had benchmarked its costs against ground transportation. But Southwest believed that cost leadership should not dilute the quality of service. According to analysts, who had been tracking Southwest closely, the airline s approach had a lot in common with the approaches taken by cost leaders in other industries. Southwest pursued a blanketing strategy 11 similar to that of the famous US retailer, Wal-Mart. When Southwest decided to serve a new city, it typically scheduled flights from the new city to two, three or even four destinations at which the company had previously established itself. Southwest did not commence a service between any two cities until it was able to devote the planes and personnel necessary to operate at least five to six flights a day. Like Toyota, which manufactured small batches of cars in a cost effective way, Southwest had developed competencies in turning around aircraft quickly. 11 Slashing the retail prices way below the cost, while entering a new market, and to raise them after establishing a monopoly in the market. 3 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Exhibit: I Southwest Building blocks of operational efficiency Limited passenger service. Frequent, Reliable Departures. Short-haul and Point-to-point Routes. Highly Productive Ground and Gate crews. Low-ticket fares and secondary or smaller airports. High Aircraft Utilization. Adopted from Harvard Business Review, November-December 1996. Figure (iii) Key Operational Parameters of Southwest Passenger Load Factor Aircraft Utilization 70.50% 72.00% 69% 68.10% 70.00% 68.00% 66.10% 65.90% 66.00% 64.00% 62.00% 1998 1999 2000 2001 2002 11.2 11.15 11.1 11.05 11 11.18 11.09 11.1 1998 1999 11.1 2000 2001 11.12 2002 Note: Passenger Load Factor is the percentage of a plane filled with paying passengers. Aircraft Utilization is the hours and minutes in a day a plane is used. Revenue Passenger Mile - One paying passenger flown one mile. Often referred to as the airlines industry's measure to traffic. Source: www.southwest.com 4 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Turnaround Quick turnaround held the key to operational excellence in the airline industry. Southwest attempted to reduce the turnaround time through excellent coordination among various functions pilots, flight attendants, gate agents, ticketing agents, operation agents, ramp agents, baggage transfer agents, cargo agents, mechanics, fuelers, aircraft cleaners and caterers. This was unlike other airlines, where these different functions typically worked in isolation. In 1972, Southwest had operated its flights with just three planes. The company limited the turnaround time for each plane to ten minutes or less. Southwest had managed to limit airplanes turn time to about 20 -25 minutes over the years, even though airport congestion had worsened and security regulations had become stricter. Exhibit: II Southwest: Anatomy of a 15-minute turnaround 7:55 Ground crew chat around gate position 8:03:30 Ground crew alerted, move to their vehicles 8:04 Plane begins to pull into gate; crew moves towards gate 8:04:30 Plane stops; Jet way12 telescopes out; baggage door opens 8:06:30 Baggage unloaded; refueling and other servicing underway 8:07 Passengers off plane 8:08 Boarding call; baggage loading, refueling complete 8:10 Boarding complete; most of ground crew leaves 8:15 Jet way retracts 8:15:30 Pushback from gate 8:18 Pushback tractor disengages; plane leaves for runway. Source: Hit em Hardest with the mostest, Forbes, 16 th September 1991. Routing After the deregulation of the airline industry in 1978, most airlines established the hub-and-spoke13 system. The system was characterized by longer wait time for both passengers and airplanes, more planes, extra computer systems, extra salaries to ground staff and additional commissions to travel agents. Airlines also had to pay the rent for the gates, as planes were often kept idle at an airport waiting for the connecting flight. Seeing these disadvantages, Southwest persisted with its pointto-point flights between cities. It gained an advantage over other carriers by utilizing the lost time for an additional flight. Southwest also decided against interlining with other carriers. It was not in favour of keeping its planes waiting for passengers to arrive from connecting flights that were often delayed. Southwest felt that customers did not want to go out of their way and travel to a hub city simply for the convenience of the airline. 12 13 A registered trademark for a certain kind of aircraft loading bridge, which allowed passengers direct access to an aircraft from the terminal. A system for deploying aircraft that enabled a carrier to increase service options at all airports covered by the system. It used a strategically located airport (the hub) as a passenger exchange point for flights to and from outlying towns and cities (the spokes). 5 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Southwest s point-to-point route system, as compared to hub-and-spoke, provided for more direct nonstop routings for customers and, therefore, minimized delays, and total trip time. In 2002, Southwest served 338 nonstop city pairs. As a result, approximately 77 % of Southwest s customers flew nonstop. Figure (iv) Southwest s System Map 2002 Source: southwest.com Use of Smaller Airports Southwest avoided congested airports wherever possible. Instead, it concentrated on convenient, efficient airports like Dallas Love Field and Houston Hobby and enhanced the company s ability to sustain high employee productivity and reliable on time performance. This dependence on secondary airports in major markets made it difficult for passengers to transfer from other airlines to Southwest flights or vice versa. But it saved an average of 15% to 25% of flight time due to reduced taxi time, fewer gate holds and less waiting in the air. This strategy also enabled the company to achieve high asset utilization. 6 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Figure (v) Southwest s Top Ten Airports Daily Departures Source: southwest.com Ticketing In 1979, Southwest introduced self-ticketing machines in ten cities to make it faster and more convenient for people to fly. This helped in reducing the time each customer spent in line waiting to be ticketed. In this system, a customer inserted a credit card into the machine, and obtained a one-way or round trip ticket for the chosen destination. The system reduced ticketing time to one minute. In January 1995, Southwest was the first major airline to introduce a ticket less travel option, eliminating the need to print and then process a paper ticket altogether. Southwest also entered into an arrangement with SABRE14, the computer reservation system, to facilitate ticketing and automated booking in a very cost-effective manner. This allowed the customers to bypass the existing computer reservation systems completely. Instead, they received a confirmation number from Southwest when they logged on to the company s website. Southwest eased the airport workload for the employees and customers by allowing for Rapid Rewards15 credits at the time of reservation rather than at the airport. This meant one less step for the employees and greater convenience for the customers. Increased Internet sales forced Southwest to close its call centers in Dallas, Little Rock, and Salt Lake. Nearly 2,000 workers were asked to relocate to another call center or accept a severance package. The customers had the opportunity to receive Rapid Rewards, after purchasing and flying only eight roundtrips. They would earn 16 credits (a one-way ticket equals one credit) in a 12-month period, and receive a roundtrip ticket for travel anywhere within Southwest s area of service for up to a year. Since there were no restrictions on the number of Rapid Rewards seats, customers could fly virtually anytime to any Southwest destination. Rapid Rewards members could also transfer (but not sell) the award ticket to anyone without any additional paperwork. Rapid Rewards program was simple and by far 14 15 The SABRE Group was a world leader in the electronic distribution of travel and travel-related services, and was a leading provider of information technology solutions for the travel and transportation industry, including customized software development and software products, transaction processing, systems integration, consulting and total information technology outsourcing. The SABRE Group provided Southwest with data processing services including computerized reservations and inventory control, flight availability information, schedules, fares and pricing. It was a promotional activity in which concessions were given in fares. 7 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines the most generous in the industry. The tickets bought were nonrefundable but could be used toward future travel on Southwest, without the penalty of a change fee. The awards for Best Customer Service, Best Award Redemption, and Best Bonus Promotion among all frequent flyer programs were earned by Southwest. Boarding To reduce check in times, Southwest automated various procedures. It implemented computergenerated baggage tags to electronically capture bags checked by customers. It also implemented computer-generated boarding passes from multiple points in the airport. This allowed customer identification by name for boarding purposes and allowed the customer a more convenient check in through standing in fewer lines. Southwest also implemented self-service boarding pass kiosks, or Rapid Check-In. Southwest did not assign any particular seat number to its customers. They were boarded on a first come first serve basis in a group of 30. Southwest used reusable plastic boarding p asses to speed up the boarding process. Earlier, the employee collecting the passes, had to read what was printed on the ticket instead of simply looking at the color of the plastic boarding pass. This slowed down the operation. Also, airline employees could not concentrate on welcoming customers on board. In flight services Southwest did not offer full cabin service and provided only coach class service to its passengers. Southwest served no meals on board. Instead , the airline offered peanuts and other snacks and put extra seats in the empty space that would otherwise be required for food galleries. Southwest also avoided using bulky food and beverage carts that prevented customers from moving about the cabin. Aircraft Standardization Southwest concentrated heavily on one type of aircraft - the Boeing 737, to simplify scheduling, maintenance, flight operations, and training activities. It gave extensive training to all its pilots, flight attendants and mechanics on the Boeing 737. The airline could easily substitute the aircraft, reschedule flight crews or transfer mechanics quickly. With only one type of aircraft, spares inventory management and record keeping became simpler. Exclusive use of the Boeing 737 series helped the company to negotiate better deals with Boeing and fuel efficient and lower capital than the other aircraft in the market. Southwest s efficient flight dispatch system allowed the airline to minimize weather and operational delays. Southwest also used a young fleet of aircraft (average age of 8.4 years) and an efficient maintenance team to minimize delays and cancellations due to mechanical problems. Looking Ahead Southwest planned to add two more nonstop flights between Baltimore and Houston by 2004. With the additional flights, Southwest would offer a total of four daily nonstop flights between the two airports. Southwest planned to connect with a new daily nonstop service between Spokane and Las Vegas on January 18, 2004. Southwest also had plans to add one daily nonstop flight between various cities from April 4, 2004. These included Chicago midway and Ft. Lauderdale/Hollywood, Chicago midway and Orlando, Chicago midway and Columbus, Baltimore/Washington and Columbus (A total of 12 flights daily). Southwest confirmed, it would start a new service from Philadelphia on May 2004, with daily nonstop service to Chicago midway, Las Vegas, Orlando, Phoenix, Providence, and Tampa Bay. 8 License for IBS Hyderabad, Sem II, Class of 2014. Operations Management at Southwest Airlines Bibliography 1. Eric Gillian, Southwest, Northwest jump on upgrades, www.thestreet.com, 12th October 2003. 2. Elizabeth Souder, High costs prompt Jet blue, Southwest 4Q warnings, Dow Jones business news, 5th December 2003. 3. Southwest Airlines boosts nonstop service in five cities, www.yahoofinance.com, 11th December 2003. 4. Southwest Airlines reveals Philadelphia service, Carrier announces nonstop destinations from its newest city, www.yahoofinance.com, 11th December 2003. 5. www.thewasington news.com 6. www.fed.org 7. www.hooversonline.com 8. www.Southwest.com 9. www.americancitybusinessjournalonline.com 9 License for IBS Hyderabad, Sem II, Class of 2014.

Formatting page ...

83060359 chat

Horizontal lines at:
Guest Horizontal lines at:
AutoRM Data:
Box geometries: